Van, Truck, Trailer, Bus and Coach Aftermarket News in Ireland

J&S Automotive launches new diesel anti-bacteria from JLM

JLM-anti-bacteriaJ&S Automotive has launched a new diesel anti-bacteria from JLM, which keeps algae out of diesel and biodiesel fuel (storage) tanks, diesel distribution systems and fuel systems.

Fuel made of petroleum consists of environmentally hazardous components, including highly toxic sulphur. Biofuel is made from a combination of natural oils or fats. The key environmental benefit of biodiesel is that this pure vegetable oil (PVO) is biodegradable. Biodiesel does not contain any toxic substances, such as sulphur, aromatics or other environmentally hazardous components.

In order to reduce the amount of toxic exhaust gases, governments require fuel suppliers to mix a prescribed percentage of biodiesel with diesel obtained from petroleum. Since 2008, a worldwide standard has been in force which stipulates the maximum permissible amount of sulphur in fuel. The level of sulphur is reduced by mixing biodiesel with petroleum diesel. More and more countries are making the use of biodiesel mandatory, with the mixing percentage varying between countries. Diesel containing biodiesel can be recognised by the letter B followed by a number; B5, B15, B20 or B90 are most commonly found. The numbers 5, 15, 20 and 90 indicate the percentage of biodiesel present in the diesel fuel obtained from petroleum.

Algae as raw material for biodiesel

One of the raw materials for biodiesel is algae. To an increasing extent, algae diesel is considered to be the third generation of biofuels and as a result, its use is on the rise. All fuels contain a certain amount of water. Diesel is less refined (filtered) than petrol, so it contains more water. Biodiesel is hygroscopic, which means that it attracts moisture from the surrounding area due to its chemical composition. The combination of having relatively more water in standard diesel and the hygroscopic properties of biodiesel therefore means that a lot of moisture is present.

Algae like moisture; it makes them grow. Just like other plants, algae also grow more quickly as the temperature rises. One property of sulphur is that it limits the growth of algae. However, as the amount of sulphur in the fuel is gradually decreasing nowadays, the algae have more of an opportunity to multiply in the fuel storage system and the fuel system.

Sludge blocks fuel system

Algae can be identified visually as sludge and this sludge accumulates in the fuel storage system and the fuel system. The sludge spreads from the fuel tank to the fuel filter via the fuel pipes. The fuel filter of a diesel engine contains a water separator that collects the moisture in the diesel and prevents it from entering the fuel pump, diesel injectors and engine. The algal sludge accumulates in the filter and will block the filter after a while. The result of this is that the engine will run more and more poorly and at a certain point it will no longer even start, as the fuel is prevented from entering the engine.

The car will then have to be taken to a workshop. In the workshop it will be discovered that there is sludge in the fuel filter, after which the filter will be replaced by the mechanic. The vehicle will now drive well again and the car owner will be on his way. However, this will almost certainly only be for a short period of time. The algal growth in the fuel tank and pipes will continue as before and the issues will start all over again very soon. The engine will start to run poorly again and the customer will have to return to the garage with the same problem. That is the last thing the customer wants.

Another adverse effect of having algae in your fuel is that they may cause defects in the fuel pump and the diesel injectors. Due to strict environmental requirements, these parts have become more and more accurate and therefore more sensitive. Even the tiniest particle, invisible to the eye, may cause a severe fault in the high-tech components. The fact that the components are subject to extreme requirements makes them highly expensive. It is therefore better to avoid having to replace them.

Requirement: clean the entire fuel system

It is highly important not just to replace the fuel filter, but also to clean the entire fuel system. Diesel Anti-Bacteria contains a product that kills living organisms, such as algae. Attention: these products do not remove algal growth. In extreme cases, the amount of algal growth in the fuel system will be so great that it can no longer be cleaned with an additive. Manual cleaning is the only solution to this. After the manual cleaning, JLM Anti-Bacteria prevents algae from growing and keeps the fuel system clean.

It may happen that you have no issues with your car in your own country or during the winter, just when you are abroad or during the summer. So if you have been on holiday abroad and you car starts to run poorly after a while, just remember this article. The algae have nested in the fuel tank and are slowly but steadily spreading throughout your vehicle’s fuel system. And algae don’t consider your vehicle’s make, type or model. They are everywhere, from private cars to delivery vans and lorries. Algae appear wherever biodiesel is present.

JLM Anti-Bacteria is suitable for all fuel storage systems, fuel transport systems and all diesel engines with and without turbos, and all common rail systems that run on regular diesel fuel.